Sponsored

Fuel pump shuts off while pumping gas.

Jonny44

2.5L Hybrid
Well-known member
First Name
Jon
Joined
Jul 22, 2021
Threads
8
Messages
452
Reaction score
768
Location
Minnesota
Vehicle(s)
2025 Mav hybrid AWD XLT, 2016 Ford Escape Titanium
Engine
2.5L Hybrid
Clubs
 
Check your filler pipe for a clog in the vent line (small tube attached to the filler pipe). Common for insect intrusion.
Ford Maverick Fuel pump shuts off while pumping gas. 1780675980875-ka
 

HeyBales

2.5L Hybrid
Well-known member
First Name
Mike
Joined
May 3, 2024
Threads
4
Messages
4,843
Reaction score
4,400
Location
KC Metro area
Vehicle(s)
2005 Toyota RAV4, 2024 XLT Hybrid
Engine
2.5L Hybrid
If you are standing out of your door where it's quiet enough - can you hit the fuel release and hear a sound back by the tank area?
Relay is getting thrown to release the pressure just before the door pops - or it should.
Maybe that didn't happen once.
But seems odd a sensor didn't pickup on that, and refuse to open the door.
Or sensor is bad, or relay, or valve.
Seems posters have shared their pics when some of those happen - indeed a dashboard light/warning goes off.
 

Johnkn

2.5L Hybrid
Well-known member
Joined
Jan 19, 2022
Threads
73
Messages
2,289
Reaction score
3,419
Location
MD
Vehicle(s)
Bronco Raptor, TRX, Viper, 66 Shelby, 68.5 CJ Mustang, Pantera
Engine
2.5L Hybrid
Try a different pump at a different station....




.
 

MakinDoForNow

2.5L Hybrid
Well-known member
First Name
James
Joined
Sep 24, 2021
Threads
2
Messages
8,438
Reaction score
6,006
Location
Texas
Vehicle(s)
2022 Maverick
Engine
2.5L Hybrid
Tried filling up twice. Pump shuts off every few seconds, spits gas out. Takes forever to fill. After the 2nd fill, the check engine light came on. Maverick 2023 hybrid.
Don't stick filler nozzle in quite as far. If you hold the pump handle too high up it will restrict the flow and pump will shut off. Also try setting the pump retainer setting to the lower speed.
 

Sponsored

Drew304

2.0L EcoBoost
Well-known member
First Name
Drew
Joined
Sep 16, 2025
Threads
1
Messages
49
Reaction score
79
Location
North Carolina
Vehicle(s)
2025 Lobo
Engine
2.0L EcoBoost
I’ve had that happen on another car I owned years ago, a G35, it would do it when it was hot would act like that. Never found the read reason though.
 

BlueSpec1

2.5L Hybrid
Well-known member
First Name
Gene
Joined
Jul 10, 2022
Threads
3
Messages
778
Reaction score
788
Location
Texas
Vehicle(s)
23 XLT 2.5L, 22 Escape Plug In, 23 Bolt EUV
Engine
2.5L Hybrid

CajunMick

2.0L EcoBoost
Well-known member
First Name
Heman
Joined
Oct 15, 2023
Threads
48
Messages
987
Reaction score
706
Location
Houston, Texas
Vehicle(s)
2023 XLT Maverick
Engine
2.0L EcoBoost
I watch others filling their vehicles at a pump. Seen them click, hand pumping with gasoline pouring out the tank filler. Mistake. Could put raw gas into the vapor collection can, and that could thrown a CEL light up.
 

Randorita

2.5L Hybrid
Well-known member
First Name
Randy
Joined
Sep 7, 2024
Threads
0
Messages
297
Reaction score
393
Location
Mississippi
Vehicle(s)
2021 Toyota RAV4, 2025 Maverick Lariat
Engine
2.5L Hybrid
I had this happen once when I was on a trip. I got about 3 or so gallons and gave up. It was fine on the next stop, so I am pretty sure it was the pump. Try filling up at a different place.
 

Cherokee

2.0L EcoBoost
Well-known member
Joined
Jan 3, 2025
Threads
49
Messages
3,707
Reaction score
6,911
Location
North Carolina
Vehicle(s)
2004 Ford Escape Platinum, 2024 Ford Maverick Lariat 2.0L AWD
Engine
2.0L EcoBoost
OP,
U sure your inserting the nozzle al the way ?
 
Sponsored

garyp

2.0L EcoBoost
Active member
First Name
Gary
Joined
Oct 23, 2025
Threads
1
Messages
37
Reaction score
46
Location
Washington
Vehicle(s)
22 ford maverick
Engine
2.0L EcoBoost
This is not an uncommon problem on earlier vehicles. I had the same problem on my 22. First dealership said they fixed it, still had problems took it to a different dealer dealership a couple months later, fixed it but charged $1200. Should have been fixed under warranty (22000 miles) anyway won’t be back to the Bremerton Ford dealership again
 

Parts Russ

2.5L Hybrid
Active member
First Name
Russ
Joined
Jun 30, 2023
Threads
0
Messages
33
Reaction score
13
Location
Hinton Alberta
Vehicle(s)
2023 Maverick
Engine
2.5L Hybrid
There are a few possibilities for this happening. All of what I have seen in the comments are valid and possible causes. My guess would be a plugged emissions canister or line. The main cause for this is either intrusion from a foreign source such as i read earlier an insect stuck in the vent tube or fuel getting into the canister. The way that this happens and ive seen it come through our shop a lot is over filling the fuel tank. The prevention for this is that when you are filling up and the pump kicks out don't "top it up" by squeezing just a bit more in. I did this for a lot of years and never realized the problem I was causing.
 

Johnkn

2.5L Hybrid
Well-known member
Joined
Jan 19, 2022
Threads
73
Messages
2,289
Reaction score
3,419
Location
MD
Vehicle(s)
Bronco Raptor, TRX, Viper, 66 Shelby, 68.5 CJ Mustang, Pantera
Engine
2.5L Hybrid
There are a few possibilities for this happening. All of what I have seen in the comments are valid and possible causes. My guess would be a plugged emissions canister or line. The main cause for this is either intrusion from a foreign source such as i read earlier an insect stuck in the vent tube or fuel getting into the canister. The way that this happens and ive seen it come through our shop a lot is over filling the fuel tank. The prevention for this is that when you are filling up and the pump kicks out don't "top it up" by squeezing just a bit more in. I did this for a lot of years and never realized the problem I was causing.
No one here knows whether the reported concern is a vehicle issue or a pump issue until the OP cuts the problem in half a tries different pumps at different stations.

Only then will it be known on which side the issue lies...

And the OP has not returned......

.
 

garyp

2.0L EcoBoost
Active member
First Name
Gary
Joined
Oct 23, 2025
Threads
1
Messages
37
Reaction score
46
Location
Washington
Vehicle(s)
22 ford maverick
Engine
2.0L EcoBoost
With mine we tried different pumps,stations,and different people trying. One of the funny things is the service manager said there were sign that it had been over filled before to the top. Dah, every time you tried to put gas in it would not take it and over flow as the pump shut off. The problem is causing the problem
Sponsored

 
 







Top